Tranny bearing Removal???


4 replies to this topic
  • finthat

Posted March 24, 2009 - 06:37 PM

#1

:thumbsup: Is there a special tool to pull the trans bearing out of the case where the clutch shaft comes across? Or is there a trick to it?

  • finthat

Posted March 24, 2009 - 06:48 PM

#2

By the way I think it is part number 93306-00431-00 if you look it up in the parts fiche on this site at the TT store.

Visit the ThumperTalk Store for the lowest prices on motorcycle / ATV parts and accessories - Guaranteed
  • 642MX

Posted March 24, 2009 - 06:53 PM

#3

Are you talking about the actuator shaft bearing?

  • txmxer

Posted March 24, 2009 - 07:20 PM

#4

If were talking about the same bearing you can put some ice on the bearing itself, then heat the case (only areas surrounding the bearing) and then it should come out quite easy. If you watch the rockymountain bottom end rebuild videos on youtube one of them mentions it.

  • grayracer513

Posted March 24, 2009 - 08:25 PM

#5

:thumbsup: Is there a special tool to pull the trans bearing out of the case where the clutch shaft comes across? Or is there a trick to it?

Yes there is. You need a blind bearing puller. Some car parts places or rental outlets will rent you one.

Heating the case to 260 ℉ (use an oven if possible, if not, heat until spit bounces off) will help. Handle it with gloves while it's that hot. Sometimes you can simply slap the heated case down on a wood bench and dislodge the bearing, but the puller is the way to go.

Posted Image





Related Content

Forums
Photo

Snake pit oct 30th by The Anvil


Dirt Bike   Dirt Bike Regional Discussion   California
  • Hot  293 replies
Forums
Photo

2016 YZ450 by CaptainKnobby


Dirt Bike   Dirt Bike Technical Forums   Suspension
  • Hot  59 replies
Wiki
WR Camshaft Swap Info - last post by jamesm113

WR Camshaft Swap Info


Articles
  • 0 replies
Forums
Photo

yz250x vs 450 4t comparisons (preferably desert riding) needed by JakeNorthrupYZ450F


Dirt Bike   Make / Model Specific   Yamaha   Yamaha 2-Stroke
  • 9 replies
Forums
Photo

YZ450F 03 Sparks driving me crazy by SirAttard


Dirt Bike   Make / Model Specific   Yamaha   YZ 400/426/450
  • 5 replies
 
x

Join Our Community!

Even if you don't want to post, registered members get access to tools that make finding & following the good stuff easier.

If you enjoyed reading about "" here in the ThumperTalk archive, you'll LOVE our community. Come join ThumperTalk today!

The views and opinions expressed on this page are strictly those of the author, and have not been reviewed or approved by ThumperTalk.