06 450f still wont run


2 replies to this topic
  • miqua343

Posted March 27, 2015 - 05:20 PM

#1

So....rebuilt top end including valves after oring leaked out all coolant. Water Pump is good. Engine runs with choke pulled and throttle response good. With choke off throttle response is slow. Engine stuters and pops when trying to rev up only on bottom end. Once past 1/4 throttle runs like a top. When decelerating it acts like ignition is intermittent once engine gets to lower rpm. Dies right away but generally starts right back up.Have cleaned carb, swapped carb, swapped coil on plug, and valve setting is good. WTF? Getting my butt kicked. Checked voltage to tps good, ohms good. Still runs bad not smooth on low rpm to 1/4throttle. Noticed on last time testing now quite a bit of oil pucking out breather hose off top of valve cover. If i cant get this solved gonna have to go with plan b which doesnt end well! Help!

Visit the ThumperTalk Store for the lowest prices on motorcycle / ATV parts and accessories - Guaranteed
  • WilfulLemar20

Posted March 27, 2015 - 06:20 PM

#2

Try putting another cdi on it if you have another avaliable seems about the only thing you have not tried

  • grayracer513

Posted March 28, 2015 - 06:15 AM

#3

Your pilot jet is partially blocked.

 

http://www.thumperta...o/#entry6879695







Related Content

Forums
Photo
Supercross

Wilson the Blue Privateer by jetfuel


Dirt Bike   Special Interest Forums   Pro Racing
  • Hot  50 replies
Wiki
WR Camshaft Swap Info - last post by jamesm113

WR Camshaft Swap Info


Articles
  • 0 replies
Forums
Photo

Snake pit oct 30th by The Anvil


Dirt Bike   Dirt Bike Regional Discussion   California
  • Hot  293 replies
Forums
Photo

Should I buy this bike? help....... by Numsa Hul


Dirt Bike   General Dirt Bike Forums   What bike should I buy?
  • * * * * *
  • 10 replies
Forums
Photo

BIGBORE FOR YZ450F 2006? by Taattie94


Dirt Bike   Make / Model Specific   Yamaha   YZ 400/426/450
  • 1 reply
 
x

Join Our Community!

Even if you don't want to post, registered members get access to tools that make finding & following the good stuff easier.

If you enjoyed reading about "" here in the ThumperTalk archive, you'll LOVE our community. Come join ThumperTalk today!

The views and opinions expressed on this page are strictly those of the author, and have not been reviewed or approved by ThumperTalk.