426 Rekluse - tough pull


3 replies to this topic
  • ATKsm

Posted May 20, 2014 - 04:42 AM

#1

I put the EXP in the other day and believe I have it adjusted properly but haven't gotten to ride it yet. The clutch pull is now horrendous instead of just bad. Is this normal? I've installed 1 Dynaring on my KTM Exc and MXC, and Rekluse on my 950 - all hydraulic clutches. The pull got a little heavier but not bad.

 

So is this normal? I searched and came up with tons of results but not what I'm looking for.

Going riding this weekend and need to make sure it's sorted before I drive almost 4 hours to get there.



  • billygildark5007

Posted May 24, 2014 - 08:00 PM

#2

I have the rekluse exp as well. Yes the clutch pull was hideous with the supplied clutch springs, but it needs them to operate correctly. The answer for me was the moose easy pull ratio box. $40 and well worth it!!! You'll need to reroute your clutch cable because of the extra length. Chose a path where the cable is as straight as possible and the curves are as long as possible. Then lube the cable while your at it and you will be impressed. The only hard part is correctly setting your free gain after install because of all the adjustment points.

Visit the ThumperTalk Store for the lowest prices on motorcycle / ATV parts and accessories - Guaranteed
  • ATKsm

Posted May 28, 2014 - 08:33 AM

#3

Thanks.
I ran it in the woods and found I never needed the lever so I guess it's not going to be an issue. Plenty of grunt to get up some rock ledges and over logs.
IT is dying sometimes on abrupt throttle chops like spinning around a tree but I think it is running rich a bit.
Now I just need to quiet the exhaust about 10dbs....fresh repack before ice season and it was still quite loud.

  • grayracer513

Posted May 28, 2014 - 09:04 AM

#4

IT is dying sometimes on abrupt throttle chops like spinning around a tree but I think it is running rich a bit.
 

 

That's what does that; idle's too rich.







Related Content

Forums
Photo

Megabomb Fitment by 288yz450


Dirt Bike   Make / Model Specific   Yamaha   YZ 400/426/450
  • 1 reply
Forums
Photo

James Stewart back on a YZ450F by YamaLink


Dirt Bike   Special Interest Forums   Pro Racing
  • Hot  47 replies
Forums
Photo
Motocross

Thinking about Yamaha 250... by Arctic Pride


Dirt Bike   Special Interest Forums   Pro Racing
  • Hot  491 replies
Forums
Photo

Snake pit oct 30th by The Anvil


Dirt Bike   Dirt Bike Regional Discussion   California
  • Hot  293 replies
Forums
Photo

The "going back to the other darkside" adventure... by Monk


Dirt Bike   Make / Model Specific   KTM   250/350/450/505 SX-F & XC-F (4-Strokes)
  • Hot  94 replies
 
x

Join Our Community!

Even if you don't want to post, registered members get access to tools that make finding & following the good stuff easier.

If you enjoyed reading about "" here in the ThumperTalk archive, you'll LOVE our community. Come join ThumperTalk today!

The views and opinions expressed on this page are strictly those of the author, and have not been reviewed or approved by ThumperTalk.